Blitz Kit Instructions t5o5h

Mayhems "BLITZ " Kit

WARNING PART 1: Contains Phosphoric Acid at 0.1% and this can burn your skin. PART 2: Contains Alkyldimethylbenzyl and can be considered an irritant. Please use the provided Gloves & Safety Goggles when using.

Be responsible and never leave these chemicals unattended or in the reach of children or animals. MSDS Sheets available at www.mayhems.co.uk or from [email protected]

Mayhems Blitz Cleaning System - Kit

Jan 2016

Page 1 (ver 1.5)

Mayhems "BLITZ" cleaning system Even though this is a cleaning solution it is not a long term effective inhibitor. Do not use it in your system as a coolant. This cleaning system is not safe to use around children and animals. You can dispose of the fluids down the drain once they have been diluted. Mayhems Blitz is a very effective cleaning system to clean different parts of you water cooling loop in the best way possible.

Contents • • • • • • •

250ml Mayhems Blitz Part 1 250ml (will dilute to 1 Ltr of fluid) 100ml Mayhems Blitz Part 2 100ml (will dilute to 4 Ltrs of fluid) Rubber gloves x 4 Litmus Paper

Measuring Cup Safety Goggles Instructions and Warnings (your reading them)

Part 1 Mayhems Blitz Mayhems Blitz Cleaning System - Kit

Jan 2016

Page 2 (ver 1.5)

DO NOT USE ON ALUMINIUM TUBE RADIATORS For internal use on Copper / Brass Tube Radiators only. Do not use on plated products. Do not use in a Water Cooling Loop. Do not spill on paint work and if you do, rinse off immediately. • • • • • • • •

Maximum effectiveness Rapid neutralisation of surface rust, contamination and oxidation Rigorous removal of mineral scale deposits Excellent suspension of particulates Low foaming Hard water tolerant Can be disposed of down grey-water (waste / outside) drain With "Care" this is easy to handle and straight forward to use Usage of Part 1 of the Mayhems Blitz Kit

Remove the Radiator from your water-cooling Loop/ Rig 1. 2. 3. 4. 5. 6. 7. 8.

Put on the Gloves provided in the kit. Mix Part one with deionised water / distilled water (either will do) to a ratio of 250ml of part 1 to 750ml of water. Add to the radiator and clean up any spills immediately. Tilt the Radiator to Vent any trapped air and Cap the Radiator Ports. Leave the cleaning solution in the Radiator for between 6 to 12 hours. Afterwards empty down the waste drain. Refill with Deionised water / Distilled water (either will do) and shake well and rinse out. Repeat step 5, 4 more times. Check Ph of last Flush using the Litmus Paper ( Within the Pack ) Refit the Radiator back into your loop and move to Part 2 of the cleaning system. Part 2 Mayhems Blitz Kit

• • • • • •

pH neutral (Ph7 -0.5 / +0.5) Effective neutralisation of contaminants. Good removal of slime, silt & detritus Excellent suspension of particulates Hard water tolerant Can be disposed of down grey-water (waste / outside) drain Usage of Part 2 Mayhems Blitz Kit

1. Drain existing system contents. Mayhems Blitz Cleaning System - Kit

Jan 2016

Page 3 (ver 1.5)

2. Mix Part two with Deionised water / Distilled water (either will do) to a ratio of 25ml of Mayhems Blitz part 2 to 975ml of water. Mayhems Blitz Part 2 will make up to 4 litres of cleaning solution. 3. Mayhems Blitz Part 2 will create a lot of foam. Please add to system slowly, do not over fill. 4. Ensure you vent the system of any trapped air. Do this by tilting the pc to release any trapped air from the radiator. Repeat at intervals 5. Check for leaks. Using just the pump, circulate the fluids for 12 - 24 hours continuously. Regularly check any installed filters and clean as necessary. 6. Refill with deionised water / distilled water (either will do). 7. Run for 60 minutes. Vent any Trapped air ( By Tilting PC ) 8. Empty out and refill with deionised water / distilled water (either will do) 9. Run for 60 minutes. Vent any Trapped air( By Tilting PC ) 10. Empty out and refill with deionised water / distilled water (either will do) 11. Run for 60 minutes. Vent any Trapped air ( By Tilting PC ) 12. Check Ph of last Flush using the Litmus Paper ( Within the Pack ) Empty out and fill with your favourite coolant.

WARNING This cleaning system is not safe to use around children and animals. You can dispose of the fluids down the drain once they have been diluted.

Mayhems take no responsibility for damage or injuries occurred through improper use. Mayhems Blitz Cleaning System - Kit

Jan 2016

Page 4 (ver 1.5)